Cornelius I Series Spécifications Page 23
- Page / 54
- Table des matières
- DEPANNAGE
- MARQUE LIVRES
Noté. / 5. Basé sur avis des utilisateurs
TP00952
November 26, 200118
Curtain Open
Yellow LED off Right evaporator curtain open.
Yellow LED off Left evaporator curtain open.
Prechill Mode
Condenser Fan Green LED (on or off) Condenser fan cycles on and off depending upon condenser temperature.
Compressor Green LED (on) Compressor contactor activeĆcompressor running.
Right Curtain Yellow LED (on) Right evaporator curtain closed.
Left Curtain Yellow LED (on) Left evaporator curtain closed (only if unit has two evaporators).
Fill Valve Green LED (on) Fill valve open.
Dump Valve Green LED (on) Dump valve open.
Ice-Making Mode
Green LED (on or off) Condenser fan cycles on and off depending upon condenser temperature.
Green LED (on) Water pump active.
Green LED (on) Compressor contactor active - compressor running.
Yellow LED (on) Right evaporator curtain closed.
Yellow LED (on) Left evaporator curtain closed (only if unit has two evaporators).
Harvest Mode
Hot Gas Green LED (on) Hot gas valve open.
Compressor Green LED (on) Compressor contactor activeĆcompressor running.
Yellow LED (on) Right evaporator curtain closed. When the ice falls and the curtain opens, the
LED will turn off.
Yellow LED (on) Same as above if there is a second (left) evaporator.
HARVEST BUTTON
The Harvest Button is located on the control board (See Figure 5 in the Cleaning Procedures chapter.
Manual Harvest
1. At any time after secondary start up, the machine can be put into the harvest cycle by depressing
the harvest button.
2. Pressing the harvest button will tell the microprocessor to skip directly to the harvest cycle.
3. Once the harvest cycle completes, the machine continues with normal operations.
Unit Check
1. Like manual harvest, any time after secondary start up the microprocessor monitors the harvest but-
ton.
2. If the harvest button is depressed and held for 5 seconds, the unit goes into a diagnostics mode.
3. All outputs are initially turned off.
4. Then the microprocessor powers each output individually for one second.
5. This continues from 10 minutes or until the power is cycled.
- Service / Training Manual 1
- TABLE OF CONTENTS 3
- PRODUCT PREVIEW 6
- MODEL AND SERIAL LOCATION 7
- SPECIFICATIONS 8
- TECHNICAL SPECIFICATIONS 9
- INSTALLATION INSTRUCTIONS 10
- DISPENSER INSTALLATION 11
- PLUMBING CONNECTIONS 12
- ELECTRICAL 12
- INSTALLATION CHECK POINTS 12
- START UP AND CHECK OUT 12
- November 26, 20018 13
- CLEANING PROCEDURES 14
- PREP – CLEANING PROCEDURE 15
- November 26, 2001 11 16
- OPERATIONS 17
- START UP SEQUENCE (PRIMARY) 18
- SECONDARY START UP 18
- DUMP CYCLE 18
- WATER FILL CYCLE 18
- PRECHILL CYCLE 18
- FREEZE CYCLE 19
- HARVEST CYCLE 19
- FAN CONTROL 19
- CALIBRATION MODE 19
- ADJUSTING BRIDGE THICKNESS 20
- TOTAL ICE CAPACITY 20
- ICE PRODUCTION CHECK 20
- FIGURE 10 21
- LED INDICATORS 22
- HARVEST BUTTON 23
- CLEAN CYCLE 24
- SAFETY FEATURES 25
- WATER FILL TIME OUT 25
- MAXIMUM FREEZE TIME OUT 26
- HARVEST TIME OUT 26
- BIN FULL DELAY 27
- HIGH CONDENSER TEMPERATURE 27
- OPEN CONDENSER THERMISTOR 27
- RESET OPERATION 28
- VOLTAGE CHECKS 28
- STACKING CABLE 28
- CONDENSER FAN CYCLING CONTROL 29
- THERMOSTATIC EXPANSION VALVES 29
- WATER REGULATING VALVE 30
- SERVICE STEM VALVES 30
- MOISTURE CONTAMINATION 31
- COMPRESSOR CONTACTOR 31
- Potential – 32
- Current – 32
- Capacitors 32
- LEAK DETECTION 33
- SELF-CONTAINED PRODUCTS 34
- HIGH PRESSURE SAFETY SWITCH 35
- COMPRESSOR RUN-ON 35
- TROUBLESHOOTING 36
- November 26, 200132 37
- November 26, 2001 33 38
- November 26, 200134 39
- FIGURE 16 40
- FIGURE 17 41
- XTREME ICE – KITS 42
- 631500074 43
- FIGURE 19 44
- SEE DETAIL 45
- DETAIL A 45
- SCALE 1:2 45
- 8–32 HEX 45
- REMOTE CONDENSERS 46
- REMOTE CONDENSER LOCATION 48
- November 26, 2001 45 50
- November 26, 200146 51
- FIGURE 30 52
- November 26, 200148 53
- One Cornelius Place 54
- Anoka, Minnesota 55303-6234 54
- (763) 421-6120 54
- (800) 238-3600 54
Produits connexes et manuels pour Les fabricants de glaçons Cornelius I Series
(22 pages)© 2020, manymanuals.fr. Tous droits réservés | 0.056 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Commentaires sur ces manuels