Cornelius SID650A/80 Manuel d'utilisateur

Operator’s ManualMODELS: SID650A/80SID650A/80-BSID650A/80-BCSID650W/80SID650W/80-BSID650W/80-BC220V, 60HZ, 1PHSPIRAL ICEMAKERDISPENSERPRINTED IN U.S.

791704FIGURE 4. BEVERAGE SYSTEM SCHEMATIC B MODELSCO2TANK15-50 PSIGS1 S6S5S2 S4S3123456OPTIONAL FOR DIET OR ROOT BEERREGULATORSSYRUP TANKSFILTEROPTION

891704FIGURE 5. BEVERAGE SYSTEM SCHEMATIC “BC”MODELSCO2TANK15-50 PSIGS1 S6S5S2 S4S3123456OPTIONAL FOR DIET OR ROOT BEERREGULATORSSYRUP TANKSFILTEROPTI

9 91704OPERATING INSTRUCTIONSA tem perature sensing control bulb located in t h e storage hopper starts and stops the ice-making process inresponse to

1091704L1L2BROWNBLUETPCOMPRESSORCC2STARTRELAYSTART CAPRUN CAP5R5CONTROLTRANSFORMER220CSTOP /RUNLPSHPSBIN T’STATCOMPRESSORCONTRACTORCC12HARVEST MOTORRE

11 91704YELBLUELPSFUSE 1-1/4 AMPTIME DELAYAGITATORMOTOR CAPCLEANICE MAKERRUNRUNSTOPBLUEBLUEGRNBLKBLKGRNPURYELYELREDREDREDREDREDPINKREDYELBLKHARVESTTIM

1291704HIGHPRESSURECONTROLHIGH SIDESERVICEPORTCOMPRESSORLOW SIDESERVICEPORTTXVBULBLOW PRESSURECONTROLTXVPRESSURETAPEVAPORATOREXPANSIONVALVE (TXV)SUCTI

13 91704MAINTENANCEREGULAR BASIS (or as required)Cleaning of the ice maker is recommended on a regular basis not only for sanitary reasons, but also t

14917046. Move the water float valve reservoir to the “Clean”position by lifting slightly and pulling forward t o raise thereservoir to the upper moun

15 917047. Reverse steps above to reassemble ice chute.8. Sanitize the inside of the hopper agita tor, ice chute, the hopper cover and ice drop cover

1691704F. Energize th e faucet to flush the sanitizing solution from the syrup line and f aucet. Continue to draw onthe f aucet until only syrup is di

i 91704TABLE OF CONTENTSPageGENERAL INFORMATION 1...DESCRIPTION 1...

17 91704TROUBLESHOOTING GUIDEThe f ollowing pages contain troubleshooting charts designed to aid an experienced service person in diagnosingany operat

1891704STARTDOES UNITOPERATEISICE MAKERO.K.?ISDISPENSERO.K.?ISBEVERAGESYSTEMO.K.?DONENO OPERATION OF ANYCOMPONENT.GO TO 1ICE MAKER ABNORMAL.DISPENSER

19 917041. TOTALLY INOPERATIVEPOWERPRESENT ATREAR JUNCTIONBOX?NONONONOYESYESYESYESISSUPPLY FUSEBLOWN (OR C/BTRIPPED)?CHECK FOR LOOSE CONNECTIONOR BROK

2091704NOYES2. ICE MAKER PROBLEMDOESICE MAKEROPERATE?GO TO 2.AIS ICEPRODUCED?DOESCOMPRESSORRUN?ISICE ONEVAPORATOR?GO TO 2.DGOTO2.B GOTO2.CIS ICEPRODUC

21 91704YES2.A ICE MAKER PROBLEMNOISHOPPERFULL?RUN/STOPSWITCH?PUT SWITCH INRUN POSITION.NORMAL SHUTOFF ONBIN THERMOSTAT.IS BINTHERMOSTATOPEN?ISWATERLE

2291704YES NO2.B COMPRESSOR INOPERATIVEISLINE VOLTAGEWITHIN  10%OF NAMEPLATEVOLTAGE?CHECK VOLTAGEPROBLEMS IN 1 .ISTHERMALPROTECTOROPEN?ISCONTACTORPUL

23 91704YES NO2.C NO ICE ON EVAPORATORISHARVESTTIMERRUNNING?ISEVAPORATORCOLD?ISWATER LEVELNORMAL?ISHOT GAS SOLENOIDENERGIZED?CHECKREFRIGERATIONSYSTEM.

2491704YESNO2.DFROZENEVAPORATORISAMBIENT ABOVE60F?ISVOLTAGE WITHIN 10%?CHECK VOLTAGE ITEMS IN 1.DISCONNECT PROBE WIRE FROMCONDUCTIVITY CONTROL.DOEST

25 91704YESNO2.D (CONT’D)1. CHECK ADJUSTMENT OF TIMER CAM#3. (HARVEST MOTOR)2. CHECK TIMER SWITCH #3.3. CHECK HARVEST MOTOR CAPACITOR.4. CHECK HARVEST

2691704YESNO2.E LOW ICE PRODUCTIONISWATER LEVELNORMAL?ISWATER TEMP .HIGH?ISAMBIENT TEMP.HIGH?ISICE THIN?CHECK WATER ITEMS IN 2.A.NORMAL EFFECT. INSTAL

ii91704TABLE OF CONTENTS (cont’d)PageLIST OF FIGURESFIGURE 1. ELECTRICAL WIRING INSTALLATION INSTRUCTIONS 3...FI GURE 2. INSTALLATIONS DIMENSION

27 91704YES2.F POOR ICE QUALITYNOYESISICE CLOUDY?ISICE SOFT?1. CHECK AIR PUMP.2. CHECK ADJUSTMENT OF TIMER CAM #4. (WATERPUMP)3. CHECK TIMER SWITCH #4

2891704YES3. DISPENSER PROBLEMNODOESAGITATORROTATE?1. CHECK MOTOR CAPACITOR.2. CHECK TIMER SWITCH #5.3. CHECK AGITATOR MOTOR.ISVOLTAGE ATSOLENOID103-1

29 91704YES4. BEVERAGE SYSTEM PROBLEMNOISONE OR MOREFAUCETSINOPERATIVE?1. CHECK WIRING CONNECTIONS TO IN-OPERATIVE FAUCETS.2. REPLACE INOPERATIVE FAUC

3091704MAINTENANCE/ADJUSTMENT PROCEDURESTHERMOSTAT ALTITUDE ADJUSTMENTSIMPORTANT: Adjust the bin thermostat setting only if storage hopper over fill i

31 91704CLEANING/REPLACE THE FILTER1. Remove the filter f rom the cabinet panel by sliding it forward toward the front of the unit.2. Wash the filter

3291704HARVEST TIME ADJUSTMENTW ARNING: Disconnect electrical power to the unit before servicing the timer in theelectrical box.1. Disconnect power to

33 917049AFIGURE 9. HARVEST TIMERDistributed By:Commercial Refrigeration Service, Inc.WWW.IceCubes.NETWWW.CorneliusParts.COM(866) 423-6253623-869-8881

3491704PARTS LISTDESCRIPTION PART NUMBERSAir Cooled W ater CooledDispenser Components 80 80 “BC” 80 80 “BC”Gate Slide 21491 21491 21491 21491Depressor

35 91704PARTS LIST (CONT’D)DESCRIPTION PART NUMBERSAir Cooled W ater CooledRefrigeration Components 80 80 “BC” 80 80 “BC”Compressor 60725 60725 60725

SD 99-31/16/9691704IMICORNELIUS INC.ONE CORNELIUS PLACEANOKA, MN. 55303--6234TELEPHONE (800) 238--3600FACSIMILE (612) 422--3232TECH SVC 1-800-535-4240

1 91704GENERAL INFORMATIONDESCRIPTIONThe Remcor S.I.D. (Spiral Ice Maker/Dispenser) is a unique, self-contained, counter t op style unit that autom at

CORPORATE HEADQUARTERS:Remcor Incorporated500 Regency DriveGlendale Heights, IL 60139(708) 980--6900Distributed By:Commercial Refrigeration Service, I

291704INSTALLATION INSTRUCTIONSUNPACKING INSTRUCTIONS1. With the unit upright, carefully remove the shipping crate. Inspect for shipping damage and re

391704IMPORTANT: To ensure proper ice maker operation and also to reduce the frequency of water-relatedservice problems, a water filter should be inst

49170434 7/834 3/816 5/821/2 128 15/1621/2117/811/413/16AIR DISCHARGE GRILLCONDENSER WATER OUT3/8-NPT (WATER COOLED ONLY)CONDENSER WATER IN3/8-NPT (WA

5 9170415- 7/8-IN.14-IN.5/8-IN.2-- 9/16-IN.26-IN.29- 1/4-IN.18 -3/4-IN.22-IN.1 -5/8-IN.UNIT OUTLINE FRONT3/8 DIA.4 PLACES1- 29/32-IN.1-5/8-IN.NOTE: SH

691704BEVERAGE SYSTEM“B”m odels contain beverage f aucets only and must be supplied with cold product from any remote cold plate orrefrigerated soda f